First, the daily inspection

Web Design And Seo For www.china-webdesign.com

forklift accessories - China Manufacturer

Thank you for inquiry my forklift accessories, Tel：13989310707, E-mail: sales@steelmanattachment.com

http://www.forklift-fork.com/key-forklift-accessories-156/

    1, the liquid level: lower than the nominal liquid level will shorten the battery life, and the

electrolyte is too low will cause the battery to heat damage, excavator attachment
therefore, must often pay attention to the

electrolyte adequacy.
    2, terminals, wire, cover: You must frequently check the battery terminal junctio n, the junction with the

wire due to oxidation caused by corrosion, and check whether the cover deformation, whether fever phenomenon.
    Appearance: dirty battery surface will cause leakage, so that the battery clean, dry surface at any time.
Second, maintenance
    , Add water: according to the required liquid level, add distilled water, not to add too much distilled

water in order to extend the time interval of adding water, add too much water electrolyte will overflow and

leakage.
    Charge: battery charging process will produce gas,forklift fork attachments
charging spaces should be kept well ventilated,

surrounded by open flame, the oxygen generated in the charging process, the acid gas will have an impact

around. During charging, unplug the charger plug arcing, the charger off before disconnecting the plug.

Stranded in a lot of hydrogen around the battery charge does not allow any open flame, you should open the

battery cover charge.
    3, terminals, wire, cover the repair: the profe ssional and technical personnel must be specified by the

manufacturer before proceeding.
    Clean: if not dirty, that the can be wiped clean with a damp cloth, if very dirty, it is necessary to

remove the battery from the car after washing with water to make it dry naturally.
Third, custody
    Custody places: You can not make a short circuit; cause a short circuit may have a fire due to the rain,

and may produce a small amount of hydrogen, batteries must be stored in ventilated, cool place.
    2, scrap batteries: used batteries there is still electricity, should be in accordance with the use of

battery storage safekeeping.
Fourth, the operation of the electrolyte
    1, check the specific gravity: the use of inhaled hydrometer to check the proportion of the job do not

allow electr olyte spills, and to wear protective gear.
    2, operating outside of the check: should professional advice, especially when the added electrolyte

(dilute sulfuric acid).
   
End-of-life of the battery operation
    An end-of-life battery operation: Battery close to the end-of-life period, single-cell battery electrolyte

reduction is very fast, should be a daily supplement of distilled water.
    2, the processing of used batteries: used batteries out of the electrolyte decomposition, the battery. Can

discuss whether or recycling by the battery manufacturer.
Sixth, emergency treatment
    1, the electrolyte is spilled on the skin: Flush with plenty of water
    2, electrolyte spills to the eyes: flush with water, and then receive professional medical treatment
    3, electrolyte spills to t he clothes: and immediately took off his clothes, rinse with water and then

rinse with a weak alkaline soap.
    Electrolyte leakage: electrolyte leakage to the outside, with lime, strong carbonated soda or carbonated

soda to neutralize, and rinse with plenty of water.